Printable Eye Wash Station Checklist3/29/2021
Each month, OSHA publishes a recap of noted violations and related fines levied against companies; fi nancial penalties for non-compliance often begin at 100,000 and can exceed 1 million.Emergency Shower Checklist There must be an unobtructed travel path between the hazard and the emergency shower drench.
The emergency shower drench must be installed with 10 seconds of the hazard and on the same level as the hazard. The water delivered by the emergency shower drench unit must be tepid (lukewarm). The emergency shower station should provide 20 gallons (75.7 liters) of water per minute for 15 minutes. Printable Eye Wash Station Checklist Free Stay OpenThe hands free stay open valve has to activate in one second or less. The water supply has to be sufficient to supply at least 20 gallons per minute in required pattern for 15 minutes. There has to be an easily accessible actuator and not be higher than 69 inches (173.3cm) above the floor. The emergency shower unit has to be identified with a highly visible sign and the area well lighted. The emergency shower unit should be activated at least weekly. The 15 minute flush tip: Dont forget to install a floor drain or some other means of fluid disposal that complies with local, state and federal codes. Eye wash checklist The eye wash unit must be within 10 seconds of the hazard and on the same level as the hazard and within an unobstructed travel path. The water delivered must be tepid (lukewarm) from the eye wash station. The valve actuator must be easy to locate and readily accessible to the user. The flushing fluid should be tepid and in the range of 60 degrees F to below 100 degrees F. The output flushing fluid must be within that range immediately at start-up of the equipment and remain there throughout the full 15-minute use cycle. There should be a controlled, low velocity flow, which rinses both eyes and is not injurious to user. The eye wash unit must deliver at least 0.4 gallons (1.5 liters) of water per minute for 15 minutes. A hands-free stay open valve must activate in one second or less. The eye wash unit should be connected to an uninterruptible water supply delivering 0.4 GPM. A highly visible sign should identify the eye wash and the unit should be well lighted. Emergency Shower Checklist Inspection Tag: I ts a good idea to have an Inspection Tag attached to each emergency fixture noting activation as this log also serves as important documentation upon plant inspection. Employees must be instructed in the location and receive training in the use of the emergency shower andor eyewash station. Current Emergency Shower Checklist Standards: Current standards (ANSI Z358.1 sections 4.6.2 4.6.5) require weekly activation of emergency showers and eyewashes to confi rm proper operation, along with a thorough annual inspection. While ANSI Z358.1 establishes many additional requirements, the standards identified above are commonly overlooked.
0 Comments
Leave a Reply.AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |